Product ID:M-BOND A-12 PART A
MSDS Date:09/29/1995
FSC:8040
NIIN:00N081205
MSDS Number: CFZVS

MEASUREMENTS GROUP INC

RALEIGH, NC 27611
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 919-365-3800

Preparer: R L FRIDLEY

Cage: 88952

MEASUREMENTS GROUP INC

WENDELL, NC 27591 US

Telephone: 919-365-3800

Cage: 88952

BISPHENOL A-EPICHLOROHYDRIN COPOLYMER

CAS: 25068-38-6

RTECS: SL6475000

Fraction By Weight: 60-90%

OSHA PEL N/K

ACGIH TLV: N/K

CALCIUM CARBONATE

CAS: 1317-65-3

RTECS: EV9580000

Fraction By Weight: 10-30%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

SILICA, CRYSTALLINE - QUARTZ

CAS: 14808-60-7

RTECS: VV7330000

Fraction By Weight: 5-10%

OSHA PEL SEE TABLE Z-3

ACGIH TLV: 0.1 MG/M3 RDUST

3); (ALUMINUM OXIDE) (SARA 313)

CAS: 1344-28-1

RTECS: BD1200000

Fraction By Weight: 5-10%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

IRON OXIDE

CAS: 51274-00-1

Fraction By Weight: 1-5%

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: DEPENDING ON ROUTE, FREQUENCY,
AND DURATION OF EXPOSURE THE FOLLOWING ORGANS &/OR SYS MAY BE
ADVERSELY EFFECTED: EYES, SKIN, & IMMUNE SYS (ALLERGIC RXNS). SIGNS
& SYMPS OF EXPOSURE: INHAL: UNDE R NORM CNDTNS, NO ADVERSE EFTS ARE
EXPECTED. EYE CONT: MAY CAUSE MODERATION IRRITATION. SKIN CONT: CAN
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ: IARC MONO,
VOL 68, 1997: GROUP 1. NTP 7TH ANNUAL RPT ON CARCIN, 1994:ANTIC TO
BE CARCINOGEN.
Effects of Overexposure:HLTH HAZ: CAUSE MODERATE IRRITATION. IT CAN
CAUSE DEVELOPMENT OF HYPERSENSITIVITY IN SUSCEPTIBLE INDIVIDUALS.
INGEST: THIS PRODUCT HAS LOW ORDER OF ORAL TOXICITY. IT IS NOT
EXPECTED TO PRODUCE ANY ADV ERSE EFFECTS FOLLOWING ACUTE EXPOSURE.
Medical Cond Aggravated by Exposure:SOME OF COMPONENTS IN PROD MAY
AGGRAVATE EXISTING MED CNDTNS INVOLVING SKIN/IMMUNE SYS/SPECIFIC
CHEMICAL ALLERGIES. CONSEQUENTLY, CERTAIN INDIVIDUALS MAY BE MORE
SUSCEPTIBLE TO POSS EFTS OF OVEREXP.

First Aid:INHAL: REMOVE TO FRESH AIR. ADMIN OXYG IF THERE IS DFCLTY
BRTHG. GIVE ARTF RESP IF BRTHG HAS STOPPED. OBTAIN MED ATTN W/OUT
DELAY. EYE: FLUSH W/STEADY STREAM OF WATER FOR @ LST 15 MINS.
OBTAIN PROMPT MED ATTN. SKIN: WASH W/SOAP & PLENTY OFWATER. REMOVE
CONTAMD CLTHG. LAUNDER CLOTHES BEFORE REUSING. DESTROY/THORO CLEAN
SHOES BEFORE REUSE. OBTAIN MED ATTN. INGEST: CALL POIS CTL CTR,
EMER ROOM/PHYS. UNLESS ADVISED OTHERWISE, INDUCE VOMIT BY GIVING
EITHER SYRUP OF IPECAC FOLLOWED BY 2 GLASSES OF WATER/BY STICKING
FINGER DOWN THROAT. NOTE: NO SPECIFIC ANTIDOTE IS KNOWN. THERAPY IS
DIRECTED @ PREVEN TING ABSORP, ADMIN TO SYMPS AS (SUP DAT)

Flash Point Method:SCC
Flash Point:>200F,>93C
Extinguishing Media:USE FOAM, CARBON DIOXIDE, DRY CHEMICAL WATER SPRAY
OR FOG.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.

Spill Release Procedures:VENTILATE AREA. IF NEC, EVAC IF AIRBORNE
LEVELS COULD EXCEED ESTABLISHED LIMITS. CONTAIN SPILL USING
DIKE/BARRIER. IF SUBSTANTIAL QTY IS SPILLED & CAN BE PUMPED,
RECOVER W/PUMPING EQUIP/VACUUM TRUCK. OTHERWISE COVER SPILL
W/INERT ABSORB, SUCH AS FULLER'S EARTH, CLAY/OTHER APPROP
ABSORBENT. PLACE MATL IN SUITABLE CNTNR FOR FURTHER HNDLG &
DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. AVOID CONTACT WITH EYES, SKIN, AND CLOTHING.
Other Precautions:HEATING CAN GENERATE VAPORS. USE APPROPRIATE
VENTILATION OR NIOSH APPROVED RESPIRATORS AS NECESSARY.

Respiratory Protection:WHERE EXPOSURE EXCEEDS ESTABLISHED AIRBORNE
LIMITS, USE NIOSH APPRVD RESPIRATOR, OR NIOSH APPRVD SCBA, OR NIOSH
APPRVD SUPPLIED AIR RESPIRATOR AS NECESSARY TO CONTROL EXPOSURE.
Ventilation:LOCAL EXHAUST & MECHANICAL: KEEP BELOW TLV.
Protective Gloves:IMPERVIOUS GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER . AS
NECESSARY TO PREVENT SKIN CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER USE.
Supplemental Safety and Health
FIRST AID PROC: AS THEY OCCUR, & PROVIDING SUPPORTIVE THERAPY.

Spec Gravity:1.26 (H*2O=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:BROWN VISCOUS LIQUID; FAINT EPOXY ODOR.

Stability Indicator/Materials to Avoid:YES
AMINES, MERCAPTANS, OXIDIZING AGENTS, ACIDS, STRONG BASES, AMMONIA.
Stability Condition to Avoid:AVOID CONTACT WITH INCOMPATIBLE CHEMICALS.
Hazardous Decomposition Products:OR BY-PRODS: PHENOLICS, SMOKE, SOOT,
CARBON DIOXIDE, CARBON MONOXIDE, & METALLIC OXIDES.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.